• Use of Quarry Dust to Replace Sand in Concrete An Experimental

    Use of Quarry Dust to Replace Sand in Concrete EXPERIMENTAL INVESTIGATION A. Mix proportioning Two grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of

  • Experimental Investigation on the Effect of Replacement of Sand

    100% replacement of sand by quarry dust in concrete. The compressive strength of concrete with quarry dust has 40% more strength than that of the concrete with sand. M. Shukla and A K Sachan (2000)[2] studied environmental hazardous stone dust utilization in building construction. It is found that partial replacement will not affect the strength and also solve the problem of disposal of stone dust.

  • Experimental Investigation on Self Compacting Concrete Using

    International Journal of Scientific and Research Publications, Volume 3, Issue 6, June 2013 1 ISSN 2250-3153 ijsrp Experimental Investigation on Self Compacting Concrete

  • EXPERIMENTAL STUDIES ON CONCRETE REPLACING FINE

    EXPERIMENTAL STUDIES ON CONCRETE REPLACING FINE AGGREGATE WITH QUARRY DUST WASTES 1T.Sravani, 2A.Anitha, 3D.Shanthi Kumar Assistant Professor, Department of Civil Engineering, Annamacharya Institute of Technology and Sciences, Tiruapti, Andhra Pradesh, India [email protected] Abstract Concrete is the most undisputable and indispensable material

  • GGBS and Fine Aggregate with Quarry Dust Concrete by Partial

    An Experimental Investigation on Properties of Concrete by Partial Replacement of Cement with GGBS and Fine Aggregate with Quarry Dust Dr. D. V. Prasada Rao1, C. S. Mallikarjuna2 1Professor, Department of Civil Engineering,

  • how is quarry dust produced one-touch.co.za

    Experimental Investigation on the Effect of Experimental Investigation on the Effect of Replacement of Sand by Quarry Dust in Hollow Concrete Block conventional concrete and concrete made using quarry dust

  • What are the advantages of using quarry dust as fine aggregate in

    23-05-2017· From the results of experimental investigations conducted, it is concluded that the quarry dust can be used as a replacement for fine aggregate. It is found that 40% replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases from 50%. The compressive strength is quantified for varying percentage and grades of concrete by

  • investigations on replacement of sand by graded quarry dust in

    The quarry dust used for this project ; experimental investigation on replacement of sand by quarry dust in concrete A complete replacement of sand Project Report On Replacement Of Crush Sand ; ppt of sand replacement by stone dust】》CRUSHER GROUP. View quotes. How to use Glass as Aggregate in Concrete Concrete Decor. How to use Glass as Aggregate in Concrete Jul 8, 2005

  • SELF COMPACTING CONCRETE WITH QUARRY DUST AS PARTIAL

    picture that quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand at 50% replacement with additional strength than control concrete.

  • EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT

    wage and quarry dust, M-sand is an economic alternative to the river sand. In this investigations Metakaolin, as partial cement In this investigations Metakaolin, as partial cement replacement and Quarry dust, M-sand as partial fine aggregates replacement.

  • EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT

    wage and quarry dust, M-sand is an economic alternative to the river sand. In this investigations Metakaolin, as partial cement In this investigations Metakaolin, as partial cement replacement and Quarry dust, M-sand as partial fine aggregates replacement.

  • What are the advantages of using quarry dust as fine aggregate in concrete?

    23-05-2017· From the results of experimental investigations conducted, it is concluded that the quarry dust can be used as a replacement for fine aggregate. It is found that 40% replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases from 50%. The compressive strength is quantified for varying percentage and grades of concrete by

  • investigations on replacement of sand by graded quarry dust in concrete

    The quarry dust used for this project ; experimental investigation on replacement of sand by quarry dust in concrete A complete replacement of sand Project Report On Replacement Of Crush Sand ; ppt of sand replacement by stone dust】》CRUSHER GROUP. View quotes. How to use Glass as Aggregate in Concrete Concrete Decor. How to use Glass as Aggregate in Concrete Jul 8, 2005

  • Experimental investigation of the utilization of quarry dust for

    15-03-2016· The management and disposal of fine by-products produced by the aggregate industry, ready-mix concrete and asphalt concrete installations (also known as filler or quarry dust), emerges as a major environmental problem of quarrying and construction sector.

  • Experimental Investigation on Self Compacting Concrete Using Quarry Dust

    International Journal of Scientific and Research Publications, Volume 3, Issue 6, June 2013 1 ISSN 2250-3153 Experimental Investigation on Self Compacting Concrete Using Quarry Dust K.S. Johnsirani*, Dr. A. Jagannathan**, R. Dinesh Kumar*** Associate Professor, Department of Civil Engineering* Mailam Engineering

  • Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete

    From the results of experimental investigations conducted, it is concluded that the quarry dust can be used as a replacement for fine aggregate. It is found that 40% replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases from 50%. The compressive strength is quantified for varying percentage and grades of concrete by replacement of

  • EXPERIMENTAL INVESTIGATIONS ON DURABILITY CHARACTERISTICS OF CONCRETE

    experimental investigations on durability characteristics of concrete developed by using brick powder (bp) and quarry dust (qd

  • replacement of sand by quarry dust Machine

    Experimental Investigation on the Effect of Replacement . 2015-2-14 Quarry dust can be used as an alternative to the river sand. Cost analysis shows that there is 40% savings if quarry dust is used instead of sand.

  • CHAPTER 2 LITERATURE REVIEW Shodhganga

    CHAPTER 2 LITERATURE REVIEW 2.1 GENERAL This chapter presents the literature reviewed on the effect of using crushed rock material, quarry dust in place of sand in the preparation of concrete. Some of the experimental investigations on the strength and durability behaviour of concrete on the use of quarry dust in the place of natural sand are listed here. In addition to crushed rock material, the fly

  • (PDF) Stone Dust in Concrete: Effect on Compressive Strength

    In the present investigation, an experimental program was carried out to study the workability and compressive strength of concrete made using stone dust as partial replacement of fine aggregate

  • (PDF) Stone Dust in Concrete: Effect on Compressive Strength

    In the present investigation, an experimental program was carried out to study the workability and compressive strength of concrete made using stone dust as partial replacement of fine aggregate

  • replacement of sand by quarry dust Machine

    Experimental Investigation on the Effect of Replacement . 2015-2-14 Quarry dust can be used as an alternative to the river sand. Cost analysis shows that there is 40% savings if quarry dust is used instead of sand.

  • Experimental Study on Partial Replacement of Fine Aggregate with Quarry

    dust (M 20, and M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties. As the percentage of Quarry Dust gradually increases, the Compressive strength of concrete will also increase with condition that percentage of Quarry Dust should not exceed 50%. Raghavendra Naik (2016), the

  • [email protected]: An experimental investigation on the

    An experimental investigation on the use of quarry dust as a replacement material in concrete: Researcher: Balamurugan G: Guide(s): Perumal P: Keywords: Civil engineering material in concrete quarry dust: Upload Date: 11-Sep-2015: University: Anna University: Completed Date: 01/08/2014: Abstract: River sand the most commonly used fine aggregate in concrete is newlinevery expensive

  • EXPERIMENTAL STUDY ON PARTIAL REPLACEMET OF FINE

    concrete and concrete with Quarry dust and Saw dust. To achieve economy in construction. The scopes are To study the influence of quarry dust and saw dust the mechanical properties of concrete. To compare the compressive, split tensile strength and the flexural strength using quarry dust and the saw dust with the conventional mix. EXPERIMENTAL INVESTIGATION 2.1 Materials used Fly Ash:

  • Experimental Study on Concrete and Cement Plaster Using

    experimental investigation on quarry dust concrete with chemical admixtures. An attempt has been made to replace the fine aggregate with quarry dust with an objective of utilizing the waste material. It is found that quarry dust improves the mechanical properties of concrete when used along with super plasticizers. She has reported that when the conventional fine aggregate is completely replaced with

  • Experimental Investigations on by using Quarry Dust Durability

    "For a long time concrete was considered to be very durable material requiring. We build concrete Structures in highly polluted urban and industrial areas. Aggressive marine environments harmful

  • EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT

    Anithaselvasofia S. D describes the Experimental Investigation on Quarry dust concrete with chemical admixture. The main objective of this investigation is to evaluate the possibilities of using quarry dust as a replacement to fine aggregate along with super plasticizer. The chemical admixture used for the investigation is super plasticizer compact sp430. 0%, 10%,

  • experimental investigations of quarry dust concrete

    PARTIAL REPLACEMENT OF CEMENT BY QUARRY,In this experimental investigation concrete cubes,In this experimental investigation cubes casted with partial replacement of cement by quarry dust with .

  • Research Paper EXPERIMENTAL STUDY ON PARTIAL

    Research Paper EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF CEMENT WITH QUARRY DUST Venkata Sairam Kumar N. 1, Dr. B. Panduranga Rao 2, Krishna Sai M.L.N. 3 Address for Correspondence 1,3 Asst. Professor, Dept of Civil engineering, R.V.R & J.C CE, Andhra Pradesh-522019. 2Head, Dept of Civil Engg. V.R. Siddhartha Engg College. Andhra Pradesh 520007.

  • Experimental Investigation on Workability of Concrete with

    Experimental Investigation on Workability of Concrete with Partial Replacement of Cement by Ground Granulated Blast Furnace and Sand by Quarry Dust Yogesh Soni Nidhi Gupta Research Scholar Assistant Professor Department of Civil Engineering Department of Civil Engineering RKDF Institute of Science & Technology, Bhopal RKDF Institute of Science & Technology, Bhopal Abstract Concrete is

  • addition of quarry dust in concrete YouTube

    29-08-2016· EXPERIMENTAL STUDY OF THE ENHANCEMENT OF obtained, it is found that replacement of quarry dust and marble powder in concrete addition of quarry dust in concrete . addition of quarry dust in

  • EXPERIMENTAL INVESTIGATION ON STRENGTH OF CONCRETE

    benefit to concrete. Quarry dust is known to increase the strength of concrete over concrete made with equal quantities of river sand, but it causes a reduction in the workability of concrete. Granulated copper slag (or) copper slag which is a by-product of metallurgical operations in Sterlite industries (India) Ltd., Tuticorin was used for the experimental investigation. For every tone of metal production, about 2.2

  • Suitability of Quarry Dust as Partial Replacement Material for Sand

    This project is an experimental investigation into the effect of using quarry dust with iron filing as a partial replacement for fine aggregates [sand] in concrete production. A total number of 60

  • GEOPOLYMER CONCRETE USING FLY ASH AND QUARRY DUST

    17-04-2015· EXPERIMENTAL INVESTIGATIONS OF STRENGTH CHARACTERSTIC OF GEOPOLYMER CONCRETE BY USING FLY ASH AND QUARRY DUST (WITHOUT CEMENT)

  • IRJET- Experimental Study on Partial Replacement of Fine

    In preparing concrete fine aggregate is partially replaced by quarry dust and saw dust the present investigation has been under taken to study the effect of sawdust and quarry dust, by adding

  • EXPERIMENTAL STUDY ON CEMENT BRICK WITH PARTIAL REPLACEMENT QUARRY DUST

    [1] “Experimental investigation on the effect of replacement of sand by quarry dust in hollow concrete block for different mix proportions” by h.

  • EXPERIMENTAL INVESTIGATION OF WASTE GLASS POWDER AS

    Experimental Investigation of Waste Glass Powder as Partial Replacement of Cement in Concrete International Journal of Advanced Technology in Civil Engineering, ISSN: 2231 –5721, Volume-2, Issue-1, 2013

  • details about replacement of sand by quary dust

    Study on Compressive Strength of Quarry Dust as 2016-4-10 · The compressive strength is quantified for varying percentage and grades of concrete by replacement of sand with quarry dust.

  • International Journal of ChemTech Research

    The specific gravity and fineness modulus of Quarry dust is 2.82 and 2.303. B. Paddy Husk . The Paddy husk obtained from local resources SS Rice mill, Saravanampatti, was used in concrete to cast test cubes and cylinders.